John Aston Warder - American Pomology. Apples

In digging trees, it is important to remove the soil very carefully on each side of the row to expose the roots, always holding the spade in such a position that its side and edge shall be in the direction of a radius, from the stem of the tree as a centre. Never stand facing the tree to be dug, but keep it next the elbow, at one side. On finding a root, withdraw the spade, and try again; and, having ascertained its direction, endeavor to loosen the outer extremities first. Proceed all around in this manner, and by gently swaying the trunk, the points of resistance will be indicated; these should be loosened and freed until all appear to be free, when, by grasping the collar as low down as possible, the tree is to be lifted gently and freed from the soil; no force should be used beyond that which is absolutely necessary, to lift the plant from its bed.

Fig. 23.—HARKNESS' TREE DIGGER.

In the great commercial nurseries, all this care cannot be exercised; everything must be done in the large way, and labor-saving appliances, the valuable results of human thought, but still not thinking nor observing intelligences, must be used. One of this class is the tree-digger, which, in the prairie soils, is used with very good success. It consists of a very large deep plow, without any mold-board, but with a wide sharp steel share, which is turned up at the edges, so as to cut the lateral roots at some distance from the trees. It is drawn on each side of the row, by four horses, hitched ad tandem . The trees may then easily be lifted from the loose prairie soil. The accompanying engraving shows the tree digger of Mr. E. Harkness, which is much used in the nurseries of Illinois and other Western States. The figure is sufficiently clear, without much explanation. The broad steel blade runs under the rows and is drawn by four horses, two working one before the other, or tandem , each side of the row. Some of our Western nurserymen find great advantage from the use of this digger in their free soils, and also for root pruning trees that are to remain in the rows.

In the sandy loams of New Jersey, a similar tool is used for digging peach trees, which is drawn by a span of heavy horses that are attached to the two separate beams, one being on each side of the trees. This implement is found to be entirely satisfactory in its operations.

High manuring in the nursery has been objected to by some orchard planters, who say that trees, which have been forced into a too luxuriant growth in their infancy, receive so severe a shock upon being transplanted to the open field, that they never recover. With the neglect which is so commonly accorded to young trees in the orchard, it is really wonderful how they ever survive at all, whether they had been stimulated in their culture or not. The large majority of purchasers at the nursery always select those trees which are most vigorous, notwithstanding the prejudice against stimulating the trees, and then with mutilated roots, they probably omit cutting back the limbs sufficiently, and when their neglected orchard fails, they complain of the forced trees. The change from the good cultivation of the nursery to the careless culture and even neglect of the farm, is certainly hard for the poor things to bear. Late growth, encouraged by high manuring, is injurious. There is a much more serious fault of the nursery than stimulating with manure and high cultivation, and that is the too common error of crowding the trees; but even this has its origin partly with the purchaser, who too often wishes to have his trees drawn up as high as possible; instead of demanding low heads he asks for high ones, and will sometimes offer a premium for trees that have grown in one season, the second from the root graft, eight or ten feet in a single shoot, so that he may at once calculate upon forming the head where he wants it, out of the reach of his horse; a calculation, however, which he will not realize.

The Preparation of the Soil for a nursery should be as deep and as thorough as possible, for some things it is best even to trench the ground; but generally, the thorough plowing, with a deep-tiller, or a trench-plow, will be sufficient, and if followed by the subsoil lifter, so much the better. One of the most intelligent horticulturists, and most successful nurserymen in the country, finds that he can produce a better result in depth and fineness of tilth, by using the Double Michigan plow, than he can with the spade. A piece of clover-sod thus plowed in the fall, and subsoiled at the same time, will be in fine order for nursery purposes, after a thorough cross-plowing and harrowing in the following spring. If the land has been under-drained, so much the better. There is little good land that would not be much improved for nursery purposes by tile draining.

If manure is to be applied, it may be spread upon the clover-sod before plowing, or it may be thrown upon the plowed ground at once or at any time during the winter, to be worked into the soil by the spring plowing; if composted, it may be spread just before the spring stirring.

Laying Out.—In laying out the nursery, some taste may be exercised by the planter; the sections and blocks should be distinct, and alleys should be located at convenient distances, so that all parts may be easily accessible with the wagon. The rows should be laid out straight, and they ought to be far enough apart—four feet might be a good average for nursery trees; cuttings and seedlings may, of course, be nearer. The trees should not be set too closely in the rows, one foot apart is plenty close enough for most kinds, and that is little enough room for the development of good lateral branches, or for those which have to remain three or four years before transplanting. For peaches, for dwarf pears, and indeed for any of the varieties that are to be taken from the nursery as maiden trees, a less space may be allowed—say eight inches apart. Apple stocks for budding, or for collar grafting, may be set ten inches apart, and they will have room to make very good plants, even should they remain until two years old.

Most nurserymen set out their apple grafts in the rows where they are to be grown to full size, and cultivate them from two to three years; while this saves the trouble of transplanting, the trees will not be as well assorted for size, nor will they have the benefit of the transplanting, (which will enhance their value much more than it costs, in the improved character of their roots), as have those that have been treated on the bedding plan, practiced by some nurserymen. This consists in setting the root grafts closely together, in a bed of very well prepared ground; they are covered at once with a good mulching of sawdust, which keeps the ground moist, and insures the growth of almost all the plants, while for the first season they occupy very little space, and are readily kept clean, as the mulching prevents the growth of weeds. In the fall, or in the following spring, they are taken up, assorted for size, and re-planted in the nursery-rows where they are to stand. This transplanting improves the character of their roots, which are more fibrous and shorter than in those trees which have stood three or four years without being disturbed. Purchasers, now-a-days, begin to look at the roots of their trees, as well as the tops; and it may become necessary for the nurserymen to gratify this fancy for low-headed, stocky trees, that have abundant fibres to insure their growth, and their early fruitfulness.

Culture of the nursery should be thorough; the soil should be frequently stirred, and kept mellow and loose, to insure cleanliness and thriftiness, and to make handsome trees. The mellow soil upon the surface, is, by some persons, considered equal to a good mulching, and indeed it answers the indications of one. Cultivation, to kill the weeds as fast as they appear, will admit both air and moisture; a share of both of these is retained by the mellow earth, which, thus treated, is indeed a very good mulch. The cultivation may be done with the small turning plow, with the double shovel, or with any of the many approved cultivators in use everywhere throughout the country. The surface should be kept as level and even as possible. In some soils the roller, made short enough to pass between the rows, is highly esteemed, and is considered a most valuable implement in the nursery. As a general rule, cultivation should not be continued too late in the season, but should be suspended about mid-summer, so as to prevent a late growth and to encourage the plants to finish their summer's work in time to ripen their wood thoroughly before the advent of winter. This is particularly necessary where the climate is severe, especially on new lands, where the trees are very vigorous. Upon the approach of winter, it is a good practice to plow a light furrow against the trees on each side; this protects the collar from cold, prevents heaving by the frost, and gives a good surface drainage to excess of water.