Jeffrey Eugenides - Middlesex

My grandfather’s good mood accompanied him all the way to the trolley stop. Other workers were already waiting, loose-kneed, smoking cigarettes and joking. Lefty noticed their metal lunch pails and, embarrassed by his paper sack, held it behind him. The streetcar showed up first as a hum in the soles of his boots. Then it appeared against the rising sun, Apollo’s own chariot, only electrified. Inside, men stood in groups arranged by language. Faces scrubbed for work still had soot inside the ears, deep black. The streetcar sped off again. Soon the jovial mood dissipated and the languages fell silent. Near downtown, a few blacks boarded the car, standing outside on the runners, holding on to the roof.

And then the Rouge appeared against the sky, rising out of the smoke it generated. At first all that was visible was the tops of the eight main smokestacks. Each gave birth to its own dark cloud. The clouds plumed upward and merged into a general pall that hung over the landscape, sending a shadow that ran along the trolley tracks; and Lefty understood that the men’s silence was a recognition of this shadow, of its inevitable approach each morning. As it came on, the men turned their backs so that only Lefty saw the light leave the sky as the shadow enveloped the streetcar and the men’s faces turned gray and one of the mavros on the runners spat blood onto the roadside. The smell seeped into the streetcar next, first the bearable eggs and manure, then the unbearable chemical taint, and Lefty looked at the other men to see if they registered it, but they didn’t, though they continued to breathe. The doors opened and they all filed out. Through the hanging smoke, Lefty saw other streetcars letting off other workers, hundreds and hundreds of gray figures trudging across the paved courtyard toward the factory gates. Trucks were driving past, and Lefty let himself be taken along with the flow of the next shift, fifty, sixty, seventy thousand men hurrying last cigarettes or getting in final words—because as they approached the factory they’d begun to speak again, not because they had anything to say but because beyond those doors language wasn’t allowed. The main building, a fortress of dark brick, was seven stories high, the smokestacks seventeen. Running off it were two chutes topped by water towers. These led to observation decks and to adjoining refineries studded with less impressive stacks. It was like a grove of trees, as if the Rouge’s eight main smokestacks had sown seeds to the wind, and now ten or twenty or fifty smaller trunks were sprouting up in the infertile soil around the plant. Lefty could see the train tracks now, the huge silos along the river, the giant spice box of coal, coke, and iron ore, and the catwalks stretching overhead like giant spiders. Before he was sucked in the door, he glimpsed a freighter and a bit of the river French explorers named for its reddish color, long before the water turned orange from runoff or ever caught on fire.

Historical fact: people stopped being human in 1913. That was the year Henry Ford put his cars on rollers and made his workers adopt the speed of the assembly line. At first, workers rebelled. They quit in droves, unable to accustom their bodies to the new pace of the age. Since then, however, the adaptation has been passed down: we’ve all inherited it to some degree, so that we plug right into joysticks and remotes, to repetitive motions of a hundred kinds.

But in 1922 it was still a new thing to be a machine.

On the factory floor, my grandfather was trained for his job in seventeen minutes. Part of the new production method’s genius was its division of labor into unskilled tasks. That way you could hire anyone. And fire anyone. The foreman showed Lefty how to take a bearing from the conveyor, grind it on a lathe, and replace it. Holding a stopwatch, he timed the new employee’s attempts. Then, nodding once, he led Lefty to his position on the Line. On the left stood a man named Wierzbicki; on the right, a man named O’Malley. For a moment, they are three men, waiting together. Then the whistle blows.

Every fourteen seconds Wierzbicki reams a bearing and Stephanides grinds a bearing and O’Malley attaches a bearing to a camshaft. This camshaft travels away on a conveyor, curling around the factory, through its clouds of metal dust, its acid fogs, until another worker fifty yards on reaches up and removes the camshaft, fitting it onto the engine block (twenty seconds). Simultaneously, other men are unhooking parts from adjacent conveyors—the carburetor, the distributor, the intake manifold—and connecting them to the engine block. Above their bent heads, huge spindles pound steam-powered fists. No one says a word. Wierzbicki reams a bearing and Stephanides grinds a bearing and O’Malley attaches a bearing to a camshaft. The camshaft circles around the floor until a hand reaches up to take it down and attach it to the engine block, growing increasingly eccentric now with swooshes of pipe and the plumage of fan blades. Wierzbicki reams a bearing and Stephanides grinds a bearing and O’Malley attaches a bearing to a camshaft. While other workers screw in the air filter (seventeen seconds) and attach the starter motor (twenty-six seconds) and put on the flywheel. At which point the engine is finished and the last man sends it soaring away . . .

Except that he isn’t the last man. There are other men below hauling the engine in, as a chassis rolls out to meet it. These men attach the engine to the transmission (twenty-five seconds). Wierzbicki reams a bearing and Stephanides grinds a bearing and O’Malley attaches a bearing to a camshaft. My grandfather sees only the bearing in front of him, his hands removing it, grinding it, and putting it back as another appears. The conveyor over his head extends back to the men who stamp out the bearings and load ingots into the furnaces; it goes back to the Foundry where the Negroes work, goggled against the infernal light and heat. They feed iron ore into the Blast Oven and pour molten steel into core molds from ladles. They pour at just the right rate—too quickly and the molds will explode; too slowly and the steel will harden. They can’t stop even to pick the burning bits of metal from their arms. Sometimes the foreman does it; sometimes not. The Foundry is the deepest recess of the Rouge, its molten core, but the Line goes back farther than that. It extends outside to the hills of coal and coke; it goes to the river where freighters dock to unload the ore, at which point the Line becomes the river itself, snaking up to the north woods until it reaches its source, which is the earth itself, the limestone and sandstone therein; and then the Line leads back again, out of substrata to river to freighters and finally to the cranes, shovels, and furnaces where it is turned into molten steel and poured into molds, cooling and hardening into car parts—the gears, drive shafts, and fuel tanks of 1922 Model T’s. Wierzbicki reams a bearing and Stephanides grinds a bearing and O’Malley attaches a bearing to a camshaft. Above and behind, at various angles, workers pack sand into core molds, or hammer plugs into molds, or put casting boxes into the cupola furnace. The Line isn’t a single line but many, diverging and intersecting. Other workers stamp out body parts (fifty seconds), bump them (forty-two seconds), and weld the pieces together (one minute and ten seconds). Wierzbicki reams a bearing and Stephanides grinds a bearing and O’Malley attaches a bearing to a camshaft. The camshaft flies around the factory until a man unhooks it, attaches it to the engine block, growing eccentric now with fan blades, pipes, and spark plugs. And then the engine is finished. A man sends it dropping down onto a chassis rolling out to meet it, as three other workers remove a car body from the oven, its black finish baked to a shine in which they can see their own faces, and they recognize themselves, momentarily, before they drop the body onto the chassis rolling out to meet it. A man jumps into the front seat (three seconds), turns the ignition (two seconds), and drives the automobile away.